Fuse crate diagram (fuse layout), location, and also assignment that fuses and also relays Lincoln Aviator (UN152) (2002, 2003, 2004, 2005).
You are watching: 2004 lincoln aviator fuse box diagram

Checking and Replacing Fuses
Fuses and also circuit breakers defend your vehicle’s electrical system indigenous overloading. If electrical contents in the car are no working, a fuse may have actually blown. Check the ideal fuses before replacing any type of electrical components.
Look closely at the fuse – a damaged wire within the fuse identifies blown fuses. If you space not certain or if it is too dark come see, try replacing the suspected fuse with one of the same value the you recognize is good.
In instance if you execute not have a preventive fuse, in an emergency you can pull the end fuses, which may be dispensable for regular driving (for example, audio system, tobacco lighter, OBD, seat heater, and also the like), and also use that if the amperage rating is the same.
Notice
Always switch turn off the ignition system and also the affected electrical circuit before replacing a fuse.Always disconnect the battery before servicing high present fuses.Never usage a fuse that a greater amperage rating than that indicated, or use any kind of other thing in location of a fuse, even as a short-term fix. This can cause extensive damage or even fire.If the replaced fuses blows again – call a qualified and also equipped business center.Passenger Compartment Fuse Box
The fuse panel is located listed below the instrument dashboard on the driver’s side.


1 | 30 | Moonroof motor, Driver seat switch, Driver seat lumbar |
2 | 10 | VAPS module, storage seat module, Body security module, Tire push Monitor system (TPMS), SecuriLock_x0003_ LED, Sunload/Autolamp sensor (SecuriLock_x0001_ LED (2004)) |
3 | 20 | Radio, navigation module |
4 | 5 | Front wiper module |
5 | 15 | Flasher relay (turn/hazards) |
6 | 5 | Electronic covert Antenna Module (EHAM) (antenna amplifier), Radio, Moonroof motor, Driver window motor, navigating module and microphone |
7 | 15 | Heated mirrors, DEATC module |
8 | 5 | Daytime to run Lamps (DRL) module, cook PCV valve (2004-2005) |
9 | 10 | Back-up lamps (DTRS), Electrochromatic mirror (2004-2005) |
10 | 10 | Heated backlight relay coil, Climate seat modules, assistant A/C temperature blend/mode actuator, A/C clutch relay contact |
11 | 20 | Not used |
12 | 15 | Restraints module |
13 | 10 | Brake change interlock |
14 | 5 | 2003: Cornering lamps |
15 | 5 | Instrument cluster, behind wiper module, Tire pressure Monitor device (TPMS) |
16 | 15 | 2003: Cigar lighter, OBD II, Liftgate relax relay coil and contacts |
2005: OBD II | ||
20 | 2004: Cigar lighter, OBD II | |
17 | 15 | Delayed accessory relay coil, Battery saver relay coil and contact |
18 | 5 | Not used |
19 | 15 | Washer pump |
20 | 5 | Shifter, Clock, power mirror switch, DVD |
21 | 10 | Brake pressure switch (ABS), IVD switch (2003-2004), RSC move (2005), Flasher relay |
22 | 10 | ABS/RSC module |
23 | 7.5 | 2004-2005: Liftgate release relay coil and also contact |
5 | 2003: Sunload/Autolamp sensor (SecuriLock_x0001_ transceiver LED) | |
24 | 30 | 2004-2005: Subwoofer, navigation amp |
20 | 2003: Subwoofer, Navigation | |
25 | 5 | Trailer tow battery fee relay coil, pond lamp relay coil (2003) |
26 | 5 | SecuriLock_x0003_ transceiver |
27 | 5 | Rear park assist, VAPS module |
28 | 5 | Radio, Navigation |
29 | 10 | DTRS, feeding to Fuse 28 |
30 | 5 | Instrument cluster, Compass module, auxiliary A/C relay coil |
Advertisements
Relay Box
The relays are situated on the reverse side of the passenger compartment fuse panel. To access the relays, you should remove the fuse panel.

1 | Flasher relay |
2 | Heated backlight relay |
3 | Delayed accessory relay |
4 | Not used |
5 | Battery saver relay |
6 | Not used |
7 | Not used |
Engine Compartment Fuse box Diagram
The power distribution box is situated in the engine compartment. The power circulation box has high-current fuses that safeguard your vehicle’s main electrical systems native overloads.

1 | 60 | Power Junction box (PJB) |
2 | 30 | Door locks (BSM) |
3 | 20 | 2005: Cigar lighter |
4 | 40 | Heated backlight/mirrors |
5 | 40 | Anti-lock Brake system (ABS)/Roll Stability control (RSC) module (pump) |
6 | 60 | Delayed accessory |
7 | 20 | Daytime to run Lamps (DRL) module |
8 | 20 | Electric cooling fan |
9 | 20 | Headlamp switch |
10 | 30 | ABS/RSC module (valves) |
11 | 40 | PTEC relay contacts |
12 | 50 | Ignition/Starter relay |
13 | 40 | Trailer tow relays |
14 | 15 | Brake desk lamp feed |
15 | 10 | Keep alive strength (PTEC/cluster/DEATC), Courtesy lights (2005) |
16 | 20 | Power point #3 |
17 | 20 | Rear wiper module |
18 | 20 | 4x4 module |
19 | 30 | Driver window motor |
20 | 30 | Electric trailer brake module |
21 | 30 | Memory seat module |
22 | 20 | Main exterior lamps (low beam headlamps, high beam headlamps, fog lamps) |
23 | 30 | Ignition switch |
24 | 20 | Horn relay |
25 | 20 | Power allude #1 |
26 | 20 | Fuel pump relay contacts |
27 | 20 | Trailer tow relays |
28 | 20 | Power point #2 |
29 | 60 | Power Junction crate (PJB) |
30 | 30 | Front wiper module |
31 | 30 | Climate-controlled seat modules |
32 | 30 | Passenger chair switch |
33 | 30 | Auxiliary blower motor |
34 | 20 | Right HID relay |
35 | 20 | Left HID relay |
36 | 40 | Blower motor |
37 | 15 | A/C clutch relay, TXV, Transmission, speed control |
38 | 15 | HEGO, VMV, Canister vent, IMCC-LSRC, EGR module, cook PCV (2003) |
39 | 15 | Injectors, Idle air regulate (2005) |
40 | 15 | PTEC, massive Air flow (MAF) sensor, Fuel pump relay |
41 | 25 | Coil ~ above plug, PTEC diode/relay |
42 | 10 | Right low beam (halogen) |
43 | 10 | Left short beam (halogen) |
44 | 2 | 2004-2005: Heated PCV valve (w/DRL only) |
15 | 2003: Fog desk lamp relay | |
45 | 2 | 2003-2004: Brake push Switch |
46 | 20 | High beams, Fog lamps (2004-2005) |
62 | 30 | Circuit Breaker: Power windows, Moonroof, Audio (delayed accessory) |
Relay | ||
47 | Horn relay | |
48 | Fuel pump relay | |
49 | High beam relay | |
50 | Fog desk lamp relay | |
51 | Not used | |
52 | A/C clutch relay | |
53 | Trailer tow best turn relay | |
54 | Trailer tow left turn relay | |
55 | Blower motor relay | |
56 | Starter relay | |
57 | PTEC relay | |
58 | Ignition relay | |
59 | 2003-2004: Driver brake used relay | |
Diode | ||
60 | PCM diode | |
61 | A/C clutch diode |
Auxiliary relay box
The relay crate is located on the front best fender well underneath the speed manage module.
See more: Napa 7035 Oil Filter Cross Reference, Oil Filter (Gold) Fil 7035


1 | Left HID relay |
2 | Right HID relay |
3 | Not used |
4 | EDF relay |
Rear Relay Box
The relay box is situated on the behind passenger side 4 minutes 1 trim panel. View your dealer or a certified technician for company of this relay box.

1 | Liftgate relax solenoid |
2 | Not used |
3 | Not used |
4 | Trailer tow back-up lamps |
5 | Not used |
6 | Not used |
7 | Trailer tow battery charge |
8 | Trailer tow park lamps |
9 | Not used |
10 | 2003: Puddle lamps |
Diode | |
11 | Not used |
12 | Not used |